products with a watertight reputation 6500-819 - DIGITAL MEDIA LOCKER for Bluetooth, USB, iPhone, iPod, MP3 devices and FM Radio OWNERS MANUAL Aquatic AV 282 Kinney Drive San Jose, CA 95112, USA E-mail: info@aquaticav.com US & Canada: 1 877 579 2782 International:
Fax: +1 408 559 0125 www.aquaticav.com
+1 408 559 1668 products with a watertight reputation PLEASE READ THIS INSTRUCTION MANUAL BEFORE INSTALLATION AND OPERATION Table of Contents Digital Media Locker 6500-819 FCC Statement Digital Media Locker 6500-819 1 Getting Started 3 Listening to Devices
............................................................................................ 3 1.1 Contents............................................................................................................. 3 1.2 Connections....................................................................................................... 3 1.3 12-pin Harness Connection................................................................................ 4 1.4 Mounting the Digital Media Locker...................................................................... 4 1.5 Remote Control Battery Install............................................................................ 5 1.6 Power On............................................................................................................ 5 1.7 Remote Control Synchronizing............................................................................ 5 2 Location of Controls.......................................................................................................... 6 2.1 Digital Media Locker Controls............................................................................. 6 2.2 Remote Control................................................................................................... 8
............. 9
. 3.1 Listening via USB................................................................................................ 9 3.1.2 Device Charging........................................................................................... 9 3.1.3 iPhone & iPod Compatible Models............................................................... 10 3.2 Listening via Bluetooth........................................................................................ 10 3.2.1 Pair with Bluetooth Device............................................................................ 10 3.2.2 Listening via Bluetooth Device...................................................................... 10 3.3 Listening via Auxiliary Input................................................................................. 10
........................................................................................................ 11 4.1 Enter FM Radio Mode.......................................................................................... 11 4.2 Scan or Seek FM Radio Channels...................................................................... 11 4.3 Saving Radio Channel to Memory...................................................................... 11 4.4 Listening to Saved Radio Memory...................................................................... 11 4.5 Switch between US and European FM Modes.................................................... 11 11 12 12 5 Additional Features.......................................................................................................... 5.1 External 12V Trigger............................................................................................ 4 Listening to FM Radio FCC ID:
MADE IN CHINA This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. NOTE:
The equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:
Reorient or relocate the receiving antenna. Increase the separation between the equipment and receiver. Consult the dealer or an experienced radio/TV technician for help. The manufacturer is not responsible for any radio or TV interference caused by unauthorized modications to this equipment. Such modications could void the user authority to operate the equipment. This equipment complies with FCC radiation exposure limits set forth for an uncontrolled environment. This equipment should be installed and operated with minimum distance 20cm between the radiator & your body. 6 Specications & Dimensions
............................................................................................... 6.1 Specications...................................................................................................... 6.2 Dimensions.......................................................................................................... 7 Warranty Information........................................................................................................ 13 13 13 14 2 www.aquaticav.com www.aquaticav.com 15 Patent: 8,578,081 Digital Media Locker is a trademark of Aquatic AV Inc. iPhone, iPod, iPod touch and iPod nano are trademarks of Apple Inc., registered in the U.S. and other countries. Made for iPod and Made for iPhone mean that an electronic accessory has been designed to connect specically to iPod or iPhone respectively, and has been certied by the developer to meet Apple performance standards. Apple is not responsible for the operation of this device or its compliance with safety and regulatory standards. Please note that the use of this accessory with iPod or iPhone may affect wireless performance. Product design and specication subject to change without notice. E&OE. Doc V1.5 Warranty Information Digital Media Locker 6500-819 Getting Started Digital Media Locker 6500-819 Aquatic AV offers a limited warranty of our products on the following terms:
Length of warranty 2 years on audio systems, electronics, speakers, and accessories (receipt required). Coverage This warranty covers only the original purchaser of a Aquatic AV product purchased from an authorized Aquatic AV dealer in the United States. In order to receive service, the purchaser must provide Aquatic AV with a copy of the receipt stating the customer name, dealer name, product purchased and date of purchase. Defective products Products found to be defective during the warranty period will be repaired or replaced (with a product deemed to be equivalent) at Aquatic AVs discretion. What is not covered Damage caused by accident, abuse, improper operations, theft. Any cost or expense related to the removal or reinstallation of product. Service performed by anyone other than an authorized Aquatic AV service center. Any product with the serial number or tamper labels defaced, altered, or removed. Subsequent damage to other components. Any product not purchased from an au-
thorized Aquatic AV dealer. Limit on implied warranties Any implied warranties including warranties of tness for use and merchantability are limited in duration to the period of the express warranty set forth above. Some states do not allow limita-
tions on the length of an implied warranty, so this limitation may not apply. No person is author-
ized to assume for Aquatic AV any other liability in connection with the sale of the product. How to obtain service You must obtain a return material authorization number (RMA) to return any product to Aquatic AV. You are responsible for shipping charges of returned products to Aquatic AV. Please record the model and serial number[s] of your equipment in the space provided below as your permanent record and will assist us with your factory warranty coverage. These numbers can be found on the rear of the Digital Media Locker. Model number[s]:
Serial number[s]:
1.1 Contents 6500-819 Digital Media Locker 2-Way RF Waterproof Remote Control Jack Cable (3.5mm Male to 3.5mm Male) Wiring Harness (AQ-UNH-2) Rear Mounting Bracket Owners Manual 1.2 Connections 1. 12-pin Watertight Harness The 12-pin harness supplies power and ground connections to the Digital Media Locker and four (4) speaker channel output connections from the Digital Media Locker. Do not cut or modify the 12-pin harness on the Locker side or warranty will be void. 2. FM Radio Antenna Jack Connect antenna (AQ-ANT-1 sold separately) to female antenna receptacle. For best FM performance make sure the antenna is extended to the highest achievable position. 3. Auxiliary Outputs Allows external amplifiers to be connected to power additional speakers. 4. 12V DC External Trigger Allows for an external light or relay to be triggered (350mA max load). 14 www.aquaticav.com www.aquaticav.com 3 Getting Started Digital Media Locker 6500-819 Specications & Dimensions Digital Media Locker 6500-819 1.3 12-pin Harness Connection The 6500-819 includes the universal harness AQ-UNH-2 in order to connect the dock to power and speakers. All open wire connections should be soldered and protected against water and dust for best long term performance. 6.1 Specications Media Supported media.................................... Supported media max. dimensions........... Device charging...................................... Bluetooth(A2DP and iAP)/USB/iPod/iPhone/MP3/FM 107 x 184mm (WxH) via USB Inputs USB...................................................... Auxiliary................................................ Outputs Pre-Out.................................................. FM Radio FM pre-sets............................................ US/Euro frequencies............................... Power Output voltage @ 2 Ohm......................... Output voltage @ 4 Ohm......................... Operation voltage.................................... Max current draw.................................... Standby current draw.............................. Multi-Environment Certications Waterproof / Dustproof............................ Conformal PCB coating........................... UV protection......................................... Salt/Fog protection................................. Stainless Steel mountings....................... 3 USB 2.0 1x 3.5mm Stereo Jack Socket, 1x Stereo pair RCA (4V) 3 Yes 4x 72W 4x 45W 9.6V - 14.4V DC 7A 6mA Yes IP65 (Remote Control rated IP66) Yes 500 hours stable, ASTM D4329 compliant 500 hours stable, ASTM B117 compliant Yes
(White/strip) Fuse Box Power Antenna (7) No lower than a 2 Ohm load should be used No lower than a 2 Ohm load should be used or damage may occur to the Digital Media or damage may occur to the Digital Media Locker. Locker. Make sure the polarity of speakers are Make sure the polarity of speakers are connected correctly. connected correctly. 1.4 Mounting the Digital Media Locker 1. A mounting template is included. Aquatic AV recommends using the measure twice, cut once method!
2. Once the mounting hole is complete, make sure the outside surface is clean and clear of debris. The Digital Media Locker has an exter-
nal water/dust proof gasket, but this requires a clean and at surface for best performance. 3. The Digital Media Locker has six (6) front screws. Drive the screws using a screw driver. During nal mounting apply equal pressure to all points for the best water/dust outer seal per-
formance. Make sure screws are snug and do not over tighten. 4. Review all outside surfaces of the Digital Media Locker to ensure proper water/dust seal. This is important for long term environmental protection performance for your digital media device. 194mm 118mm 66.8mm 95mm 4 www.aquaticav.com www.aquaticav.com 13 Digital Media Locker 6500-819 Getting Started Digital Media Locker 6500-819 Additional Features 5.1 External 12V Trigger Locker Aquatic AV has provided an independent 12V accessory trigger, activated from the RF wireless remote. This could activate any 12V based device like 12 V lights or 12V motors. In any operational mode, press the (12V TRIGGER) key to activate. Press again to deactivate. Aquatic AV strongly recommend you speak to our technical service staff or your local Aquatic AV dealer if you are considering using this feature. Load on External Trigger should not exceed 350mA. 1.5 Remote Control Battery Install Remove the RF wireless remote control from the Digital Media Locker box. Unscrew the water-
proof cap on the back of the remote control. Place the CR-2450 battery in the RF remote control and replace the water/dust proof cap. When the battery is installed, the remote control LCD should be solid and bright without any ickering. 1.6 Power On Press the on/off button. Red Light: Power to the docking station is ON, but the unit is in st andby mode. Blue Light: The unit is powered ON and looking for an audio sourc e. For applications that require low current draw and where battery drain may occur, the power but-
ton must be turned OFF inside the unit. When the power button is in the OFF position the red LED will not be lit. For applications where a 12V battery is not used, such as in a Spa, the power button can be left ON and the remote control or door controls can then be used to power on/off accordingly. 1.7 Remote Control Synchronizing (6560-300 sold separately) 1. Turn the Digital Media Locker to off mode with the power button inside the door. The LED should not be illuminated. 2. Press the red (POWER) button on the remote. 3. Press and hold the (MODE) button until the LCD reads PAIR. 4. Continue to press and hold the (MODE) button during step 5 below. 5. Turn the docking station to standby mode (within 10 seconds) with the on/off button inside door (the red LED will illuminate and then turn blue). 6. The remotes LCD should read WELCOME or show a mode position such as RADIO, USB, BT or AUX IN. For any additional remote controls, you will also need to activate/synchronize those remote con-
trols by following the steps above. If the pairing process is not effective, switch the locker off using the on/off button located inside the door of the dock. Unplug the 12-pin Harness on the back of the Locker for 3 minutes. Reattach the Harness and repeat steps 1-6 above. If the pairing process is not effective, check the battery voltage. If above 3V DC refer to section 1.5 above top make sure the battery is installed correctly. If battery voltage is below 3V DC replace the battery. If the LCD displays NO LINK in either mode, this means the remote is out of reception range. Move the remote closer to the Locker and try again. If you lose your remote control and buy another new remote control, please follow the above to start pairing before normal usage. 12 www.aquaticav.com www.aquaticav.com 5 Location of Controls Digital Media Locker 6500-819 Listening to FM Radio Digital Media Locker 6500-819 2.1 Digital Media Locker Controls 1 5 3 2 4 6 7 1. Open/Close Latch & Protective Door 2. Power ON/OFF Button 3. Water/Dust Protection Inner Gasket 4. 3.5mm Aux Input for MP3 Devices 5. Power ON/OFF LED 6. USB Connector 7. Phone Holder 4.1 Enter FM Radio Mode 1. Press (MODE) on remote control to switch to FM radio mode. If this is the rst time you listen to FM radio, the default frequency will be 87.5MHz, as shown on the remote LCD. FM radio is only available when you are in the FM Radio mode. 4.2 Scan or Seek FM Radio Channels 1. Press (FAST REWIND) or (FAST FORWARD) to seek another station. 2. Press and hold either (FAST REWIND) or (FAST FORWARD) for manual tuning back or forward. After using Seek mode the unit will automatically switch back into Scan mode after 20 seconds. 4.3 Saving Radio Channel to Memory To save the current frequency into memory, press and hold , or for more than 2 sec-
onds. The station will be stored into relevant button. 4.4 Listening to Saved Radio Memory Press the , or preset button once to listen to the station stored in that button. 4.5 Switch between US and European FM Modes 1. Make sure dock and remote are turned on and in RADIO mode. 2. Press the AUDIO button 6 time in a row. 3. The remote will display AREA USA or AREA EUR depending on which tuning mode is currently selected. 4. Use the and buttons to switch between US or European modes. 5. Press (PLAY/PAUSE) to select the desired tuning mode. 6. Once you switch modes it will default to the FM station stored i n PRESET. US mode will increase and decrease the FM frequency in steps of 0.1 MHz, e.g. 88.5, 88.6,88.7 MHz. EUR mode will increase and decrease the FM frequency in steps of 0.05 MHz, e.g. 88.25, 88.30, 88.35 MHz. When in Seek mode and European FM tuning mode, all frequency steps will be visible. 6 www.aquaticav.com www.aquaticav.com 11 Listening to Devices Digital Media Locker 6500-819 Location of Controls Digital Media Locker 6500-819 3.1.3 iPhone & iPod Compatible Models 3.2 Listening via Bluetooth IAP Bluetooth connectivity allows device information, such as song, playlist and album titles, to be streamed wirelessly and viewable on the remote control. 3.2.1 Pair with Bluetooth Device 1. Switch on your Bluetooth device. 2. Select BLUEWAVE from the list of available devices to pair (password 0000). Only one Bluetooth device can be paired with the Digital Media Locker at any time. 3.2.2 Listening via Bluetooth Device 1. Bluetooth mode will be activated once a Bluetooth device is linked. 2. Play the song from device and the sound will play through the Digital Media Locker. 3. Press (PLAY/PAUSE) to play/pause the song. 5. Track and volume can be controlled directly from your Bluetooth device, remote control or door controls. 3.3 Listening via Auxiliary Input 1. Power up the Digital Media Locker. 2. Connect your MP3 device to either the 3.5mm Jack input or RCA input 3. Secure the device with the anchor straps provided. 4. Secure the Digital Media Lockers protective door. 5. Press (MODE) on the remote control to select AUX IN mode. Only one Auxiliary input (3.5mm Jack or RCA) can be used at any one time. 10 www.aquaticav.com www.aquaticav.com 7 Location of Controls Digital Media Locker 6500-819 Listening to Devices Digital Media Locker 6500-819 2.3 Remote Control 3.1 Listening via USB
-
--
Always ensure to connect and disconnect your media player with dry hands!
1. Power up the Digital Media Locker 2. Attach your device to the USB cable inside the Digital Media Locker using the appropriate USB adaptor. 3. Secure the device with the anchor straps provided. 4. Secure the Digital Media Lockers protective door. 5. Press (POWER) on the remote control or Power button on the locker to turn it ON. 6. Press (MODE) on the remote control to select USB mode. Use the buttons as shown in the remote function chart. 3.1.2 Device Charging evice battery will charge. Buttons Music Mode: iPhone, iPod, Bluetooth, USB & MP3 FM Radio Mode Power Mode Audio Volume Up Volume Down Play /
Pause Fast Rewind Fast Forward 1 / DIR -
2 / Repeat 3 / DIR +
12V Trigger /
Random Press Once: Turns remote control on. Press Twice: Toggle from Operation mode to Standby mode or vice-versa. Press once: Change the source. Press and hold: No function Press once: Change the source. Press and hold: No function Audio Press and hold: Audio Menu (BAS-TRE-BAL-FAD-EUR-DX-
MONO-STEREO) Press once: Audio Menu (BAS-TRE-BAL-FAD-EUR-DX-MONO-
STEREO) Press and hold: Audio Menu (BAS-TRE-BAL-FAD-EUR-DX-
MONO-STEREO) Press once: Volume up Press and hold: Fast volume up Press once: Volume down Press and hold: Fast volume down Press once: Play/Pause Press and hold: No function Press once: Previous track Press and hold: Fast rewind Press once: Next track Press and hold: Fast forward Press once: Back to previous folder Press and hold: No function Press once: Repeat playback function Press and hold: Repeat function Press once: Forward to next folder Press and hold: No function Press once: Volume up Press and hold: Fast volume up Press once: Volume down Press and hold: Fast volume down Press once: Toggle mute Press and hold: No function Press once: Scan down Press and hold: Toggle manual seeking Press once: Scan up Press and hold: Toggle manual seeking Press once: Listen to FM preset station 1 Press and hold: Set preset FM station 1 Press once: Listen to FM preset station 2 Press and hold: Set preset FM station 2 Press once: Listen to FM preset station 3 Press and hold: Set preset FM station 3 Press once: Random playback function Press and hold: Toggle external 12V power on/off Press once: No function Press and hold: Toggle external 12V power on/off If your music player is connected via the Auxiliary input you will not be able to control track or receive track informa-
tion. In order to prolong remote battery life the LCD will shut off in 20 seconds if no other button is pressed. To turn remote back on press any key once and then press the command desired. Turn off DSP to access control of Bass and Treble When in Bluetooth mode Repeat and Random playback functions must be enabled via your media device and not from the remote control. 8 www.aquaticav.com www.aquaticav.com 9