all | frequencies |
|
|
|
|
exhibits | applications |
---|---|---|---|---|---|---|---|
manual | photos | label |
app s | submitted / available | |||||||
---|---|---|---|---|---|---|---|---|
1 |
|
User Manual | Users Manual | 708.85 KiB | July 04 2017 / September 04 2017 | |||
1 |
|
Internal Photos | Internal Photos | 1.19 MiB | July 04 2017 / September 04 2017 | |||
1 |
|
External Photos | External Photos | 659.17 KiB | July 04 2017 / September 04 2017 | |||
1 |
|
Label | ID Label/Location Info | 1016.56 KiB | July 04 2017 / September 04 2017 | |||
1 |
|
Authorization | Cover Letter(s) | 13.79 KiB | July 04 2017 / September 04 2017 | |||
1 | Block Diagram | Block Diagram | April 07 2017 | confidential | ||||
1 |
|
Confidentiality | Cover Letter(s) | 35.27 KiB | July 04 2017 / September 04 2017 | |||
1 |
|
Declaration Letter | Cover Letter(s) | 59.60 KiB | July 04 2017 / September 04 2017 | |||
1 | Operational Description | Operational Description | April 07 2017 | confidential | ||||
1 |
|
RF Exposure | RF Exposure Info | 28.36 KiB | July 04 2017 / September 04 2017 | |||
1 | Schematics | Schematics | April 07 2017 | confidential | ||||
1 |
|
Test Report | Test Report | 2.78 MiB | July 04 2017 / September 04 2017 | |||
1 |
|
Test Set Up Photos | Test Setup Photos | 163.74 KiB | July 04 2017 / September 04 2017 |
1 | User Manual | Users Manual | 708.85 KiB | July 04 2017 / September 04 2017 |
RADIO / USB MP3 / WMA / DAB+ / DMB / Bluetooth 12V OWNERS MANUAL S f t SafetyInformation I f ti Thank you for purchasing this product, please read the manual carefull before operating,andreserveitfor futurereference. Precaution USE Only in a 12volt DC negative ground electrical system. Disconnect the vehicle's negative battery terminal while mounting and connecting the unit. When replacing the fuse, be sure to use one with an identical amperage rating. Using a fuse with a higher amperage rating may cause serious damage to the unit. Make sure that pins or obstacel do not get inside the unit, they may cause malfunctions, or create safety hazards such as electrical shock shock. If you have parked the vehicle for a long time in hot or cold weather, wait until the temperature in the vehicle becomes normal before operating the unit. Before operation Do not raise the volume level too high.Keep the volume at a level at which you can hear the volume ata level atwhich youcanhear outsidewarningsounds (hornssirens,etc.). Stopthevehiclebeforeperformingany complicatedoperations. Caution Caution Do not open the cover and do not repair by yourself. Ask your authorised dealer for help. Note:
1 According to models with different wiring 1 According tomodels with different wiring harness toconnect the definition ofthe specific content, please refer to the model label. 2 Specifications and the design are subject to change without notice due to improvements in technology. C Contents 2 Safety Information ........................................ 2 PanelControls ............................................... 3 General Operation........................................ 4 GeneralOperation Volume and Sound ........................................4 AM/FMRadio............................................. 5 DABRadio...................................................... 6 USB/MP3/WMA............................................. 7 Bluetooth............................................... 8 Dimming.............................................10 SystemSettingsItemsList ...............................11 Electricalconnections...................................14 15 Troubleshooting ............................................15 Troubleshooting Specifications................................................16 FCC ................................................................17 Panel Controls PanelControls 3
(1) Microphone
(2) Powerbutton On/Off Mute RotatetheVOLknobtoadjustvolume
(longpress)
(shortpress)
(3)SourceButton S l SelectSource SelectPTYMode t S
(4)Band/ASTButton
( h t
)
(shortpress)
(longpress) Bandselect Autostore/DABServiceScan
(shortpress)
(longpress)
(5)
(5) Select Button SelectButton ManualandAutomaticEqualizing SelectMenuentryinuserMenu
(6) Display button
(6)Displaybutton DisplaySystemclock, DisplayPTYInformationinRadiomode DisplayMP3Information(USBMode)
(7)<<Button PreviousStation/PreviousTrack
(8)>>Button NextStation/NextTrack
(9) USBslot
(10 15)AM/FM, DABFavorites
(10)
(10)
(11)
(12)
(13)
(13)
(14) MP3 folder ahead MP3 folderahead Phone:Hangup MP3folderback Phone:Contactmode/Dial/Calltransfer MP3Randomplay MP3 repeat play MP3repeatplay ProgramintroPlay(Scan)
(15)MP3/BluetoothPlay/Pause GeneralOperation SwitchingON/OFF,Mute ToSwitchontheRadiopushthePOWERON/OFF button button. ToswitchoftheRadiopushthePOWERON/OFF buttonformorethan2sec. TheRadiowillbemutedbypushingthePOWER ON/OFFbuttonforlessthat2sec. IgnitionLogic Withignitionlogicactivated(Defaultsetting)the Radiocanbeswitchedonandoffmanuallyevenif thevehiclesignitionpinisnotconnected.Toavoid battery discharge the radio is switched of after 1h batterydischargetheradioisswitchedofafter1h withoutuseroperation. SystemSettings Thesystemsettingsmenuisenteredbylong pressing the [DISP] button To access the available pressingthe[DISP]button.Toaccesstheavailable menuentriespushthesearchbuttons[<</>>].To selecttheavailableoptionsofeachmenuentry rotatethe[VOL]knob. Fordetailsseechaptersystemsettingsofthis manual. SelectSource Pressthe[SRC]buttontoswitchbetweenand select available sources: TUNER >USB >AUX selectavailablesources:TUNER>USB>AUX
>Bluetooth>DAB.USBandBluetoothisonly visibleinthemenuwhenconnected. ReceptionArea ThisRadioisdesignedtoworkindifferentregions withdifferentfrequencyranges. q g y TheReceptionareacanbeadjustedviatheSystem Settingsmenu.ThedefaultsettingisEUROPE. ThefollowingAreasareavailable:
EUROPE/ASIA/JAPAN/NORTHAFRICA/USA ClockSetting Theclocktimecanbeadjustmanuallybylong pressingthe[DISP]buttontosetthetime. Select[CLOCK]withthesearchbuttons[<</>>]. Press[SEL]buttonandrotate[VOL]knobtoadjust theminutes. Presssearchbuttons[<</>>]toselectadjust hours.Rotate[VOL]knobtoadjustthehours. Pressthe[SEL]buttontoexittheclocksetting. 4 VolumeandSound Volume ToadjusttheVolumerotatethe[VOL]knob Predefinedsoundeffects TheRadioprovidesdifferentpredefinedsound effects. Pressthe[SEL]buttontoentertheSoundsettings menu.Rotatethe[VOL]knobtoselectoneofthe following options: EQ OFF > POP followingoptions:EQOFF>POP
>ROCK>CLASSIC>JAZZ>CUSTOM. BALANCE,FADERandLoudness ToadjustBalance,FaderandLoudnesspressthe
[SEL]buttonandthenpush[<</>>]buttonto selectBALANCE>FADER>LOUDNESS.Rotatethe
[VOL]knobtoadjustBalance,FaderandLoudness accordingyourneeds. ManualSoundAdjustment FormanualsoundadjustmentfirstselectCUSTOM. Pushthe[SEL]buttonagainandthenselectBASSor TREBLEwiththe[<</>>]button.Rotatethe[VOL]
knobtoadjustBASSandTREBLEaccordingyour needs.
/
AM/FMRadio AM/FMRadioSelection ToaccessAM/FMRadiopressthe[SRC]button andselectTuner SelectBand Pressthe[BAND]Buttontoselectoneofthe availableRadioBands.TheRadiobandswillbe changedinthefollowingorder:
FM1>FM2>FM3>AM1>AM2>LW TheAMandLWBandscanbedeactivatedbythe userviathesystemsettingsmenu. AutomaticTuning ForAutomatictuningpressthe[<</>>]button. The Radio will search and select the next receivable TheRadiowillsearchandselectthenextreceivable station. WhenTrafficAnnouncementisactivated(TA=
ON)onlystationsthatbroadcastTraffic announcementswillbetuned. ManualStoringFavourites Thereare3FM,2AMand1LMFavouritebanks available. Selectthefavouritebankwheretostorethestation andtunethestationthatshallbestored. Pushthepresetbuttonlongerthan2sec.tostore thestation RecallStoredFavourites T Torecallastoredfavouritepushtheaccording presetbutton h h d f di ll i AutoMemoryStore Tosearchforthebestreceivablestationsandstore them as favourite press the (BAND/AST] button for themasfavouritepressthe(BAND/AST]buttonfor 2sec.TheRadiosearchesthebestreceivablestation andstoresthem. i l ManualTuning Formanualstationselectionpressthe[<</>>]
buttonforlongerthan2sec.MANUALisshownin thedisplay.Pressingthe[<</>>]buttonagainthe frequencywillbeincrementally increased/decreased. 5 RDS ManyFMStationsinEuropetransmitRDSdata
(RadioDataSystem)inadditiontotheiraudio program.WithRDStheuserhasthefollowing benefits:
Thebestaudiblefrequency(AF)ofaselected stationistunedautomaticallyforbestreception quality. Toenableautomaticselectionofbestaudible o e ab e auto at c se ect o o best aud b e frequencyselectAF=ONintheSettingsmenu TheRadiorecognizesTrafficAnnouncements andcanswitchtoRadioevenifanotherAudio sourceisselected. ToenableautomaticTrafficannouncementselect TA ON in the Settings menu TA=ONintheSettingsmenu SomeStationsprovideregionalspecificprograms. Withtheregional(REG)functiononlythose frequenciesarefollowedthatbroadcastthe selectedregionalprogram.Tofollowregional programsselectREG=ONintheSettingsmenu Thestationsnamecanbedisplayed ForfurthersettingsseeSystemMenu PTY ViatheRDSSystemFMstationsinmanycountries transmitthetypeofprogram(ProgramType,PTY) thatisbroadcasted. TosearchforadesiredProgramtypepush[SRC]for about2sec.andselecttheProgramtypebyrotating the[VOL]knob. TheRadiowillsearchforaRadioProgramwiththe selectedProgramtypewhenthe[SEL]buttonis pushed.PTYSEEKisshownintheDisplay. IfnostationwiththeselectedProgramTypecanbe foundthelasttunedstationwillbeselectedand NOPTYisshownintheDisplay. Thefollowingprogramtypesareavailable:
NEWS,AFFAIRS,INFO,SPORT, EDUCATE, DRAMA,CULTURE,SCIENCE,VARIED,POPM, ROCKM,EASYM,LIGHTM,CLASSICSM , O T H E RM , W E AT H E R, F I N A N C E ,CHILDREN, SOCIAL,RELIGION,PHONEIN,TRAVEL,LEISURE, JAZZ,COUNTRY,NATIONALM,OLDIES,FOLK M, DOCUMENT TEST ALARM DOCUMENT,TEST,ALARM DAB Radio DABRadio DABRadioSelection DAB/DAB+Providesradioprogramsindigital soundquality. T d ToaccessDigitalAudioBroadcast(DAB)pressthe
[SRC]buttonandselectDAB. l A di B
(DAB) Di h i DABServiceSCAN TosearchforreceivableDABServicestheDAB serviceSCANhastobestartedbypushing g
[BAND/AST]for2sec.SCANisshowninthe display. y p SelectDABBand Pressthe[BAND]Buttontoselectoneof theavailableDABBands.TheDABbands willbechangedinthefollowingorder:
DAB1>DAB2>DAB3 TuningaDABService TotuneaDABservicepush[<</>>]toselectthe next/previousDABservice.Tuningisshownon theDisplay. 6 DABServiceList TogetanoverviewofreceivableDABservicesa DABServiceListcanbedisplayed. Push [SEL] for 2 sec to open the DAB Service List Push[SEL]for2sec.toopentheDABServiceList. Rotatethe[VOL]Buttontoscrollthroughthelist ofreceivablestations. TotuneaDABservicepush[SEL].Tuningis shownonthedisplay. InthecasethataServiceistemporarynot receivableNoServicewillbeshownonthe display. StoringDABFavourites Thereare3DABfavouritebanksavailable. Selectthefavouritebankwheretostorethe stationandtunethestationthatshallbe stored. Pushthepresetbuttonlongerthan2sec.to storethestation Recall Stored Favourites RecallStoredFavourites Torecallastoredfavouritepushtheaccording presetbutton SwitchingbetweenDABandFM WhentheDABsignalqualitydropssignificant itisreasonabletoswitchandlistentothe service via FM serviceviaFM. SwitchingbetweenDABandFM(DABFMLNK) canbedisabledviathesystemsettingsmenu USB/MP3/WMA USB/MP3/WMA Note on MP3 MP3 is short for MPEG Audio Layer 3 and refers to an audio compression technology standard. This product allows playback of MP3 files. The unit can read MP3 files written in the format compliant with ISO 9660. However it does not support the MP3 data written by the method of packet write of packet write. USB Notes USB functions (flash memory type) MP3 music play. USB flash memory 2 in 1 support FAT 12/FAT 16/FAT 32 format supported. File name: 64 byte/dir name: 64 byte/tag name: 30 byte. Tag (id3 tag ver 2.0) title/artist/album: 32 byte support. t titl /
ti t/ lb 32 b t The unit can not read an MP3 file that has a file extension other than ".mp3". USB 1.1 support, USB 2.0 support
(For 2.0, speed performance is as USB 1.1) If you play a nonMP3 file that has the .mp3"
extension, you may hear some noise. In this manual, we refer to what are called "MP3 file" and "folder " in PC terminology as "track" and
"Album," respectively. Maximum number of directory level is 8, including the root directory. Maximum
, number of files and folders per disc is 256. g y The unit may not play tracks in the order of Track numbers. The unit plays only the audio tracks if a disc contains both audio tracks and MP3 files contains both audio tracks and MP3 files. Not all USB devices are compatible with the unit. USB connector is support maximum work power with 500 mA. Loading/RemovalofUSBDevice InsertaUSBdeviceintotheUSBslotReadingis shownontheDisplay.MP3Playbackwillstart immediateafterwards. BeforeremovingtheUSBDeviceswitchtoan otherSourcebypushingthe[SRC]button. 7 MP3Playback/Pause TopauseandresumeMP3Playbackpushbutton
[1>]. Next/PreviousMP3Track. Toselectthenext/previoustrackpushthe[<</>>]
button. Fastforward/fastrewind. To fast forward/fast rewind the current track push Tofastforward/fastrewindthecurrenttrackpush the[<</>>]buttonlongerthan2sec. RandomPlay Toactivaterandomplaypushthebutton[4RND]. Repeat Repeat Pushthe[3RPT]buttontoactivaterepeat Track/repeatdirectory/repeatall. SCAN Toactivate/stopthescanfunctionpushthebutton
[2SCN].Inscanmodealltitlesareplayedfor10 sec. Bl h Bluetooth TheBluetoothallowsyoutoutilizeyourvehicles builtinaudiosystemforwirelessmobilephone or music hands free communication. Some ormusichandsfreecommunication.Some Bluetoothmobilephoneshavetheaudio features,andsomeportableaudioplayers supportBluetoothfeature.Thissystemcanplay audiodatastoredinaBluetoothaudiodevice. ThevehiclestereowithBluetoothwillbeableto retrievephonebookcontacts,receivedcall, dialed call missed call incoming calls outgoing dialedcall,missedcall,incomingcalls,outgoing callandlistentomusic. Notes:
DonotleavethemicrophoneofBluetooth handsfreeintheplaceswithwindpassing suchasairoutletoftheairconditioner,etc. This may cause a malfunction Thismaycauseamalfunction. Ifleaveitintheplacessubjectedtodirect sun,hightemperaturecancausedistortion, discolorationwhichmayresultina malfunction. Thissystemwillnotoperateormayoperate improperlywithsomeBluetoothaudioplayers. Cannotguaranteethecompatibilityofall mobilephonestogetherwithunit. Audioplaybackwillbesettothesame volumelevelassetduringtelephonecall.This mightcauseproblems,ifextremevolumelevel issetduringtelephonecall. HandsfreeOperations d f i Pairing 1.TurnonBluetoothfunctionofyourmobilephone. 2.EntermobilephonesBluetoothsetupmenu. 3.SearchfornewBluetoothdevices. 4.SelectBluetoothdevicesfromthepairingliston themobilephone. 5.Enter1234asthepassword(Thepassword defaultsettingis1234). 6.Afterpairingsuccessfully,BTandHPFiconswill lightup. A2DP icon will light up after A2DP A2DPiconwilllightupafterA2DP connected Makingacall Pressthe[SRC]buttontoswitchthesourceto Bluetooth. Pushthe[5/]buttonandrotatethe[VOL]knobto selectoneoftheoptions:
DialNumber/UserphoneBook/Received/Dialed
/Missed.
[ / ]
[
]
h [SEL] k b DialNumber SelectDialNumber 1 P 1.Pressthe[SEL]knobonthefrontpaneltostart numberinput. 2.Rotatethe[VOL]knobtoselectadigit,pressthe
[SEL]knobtoconfirm. 3.Pressthe[5/]buttontodial. 4.Pressthe[6/]buttontoterminatecall. h f l 8 Dialed/Missed/Received YoucansearchanyDialed/Missed/Received. 1.Rotatethe[VOL]knobtoselect DIALED MISSED RECEIVED DIALED , MISSED , RECEIVED 2Pressthe[SEL]knobtoentertheselectedcall history. 3.Rotatethe[VOL]knobtoscrollthecontacts. 4.WhenthecontactnameormobilephoneNo.is displayed,pressthe[5/]buttontocallthemobile phoneNo.ofthatcontact.Pressthe[6/]buttonto endthecall. CallfromPhonebook Usercansearchthecontactnameinthephonebook andmakecall. 1.Rotatethe[VOL]knobtoselectUSERPBK. 2 Press the [SEL] knob to enter the selected 2.Pressthe[SEL]knobtoentertheselected phonebook. 3.Rotatethe[VOL]knobtoscrollthecontacts. 4.Whenthecontactnameisdisplayed,pressthe
[5/]knobtocallthemobilephoneNo.ofthat contact. Pressthe[6/]buttontoendthecall. Note:
Somemobilephonesmaynotbeabletotransfer dataofPhonebook. AudioStreaming 9 TransferCall Youcanswitchbetweenhandsfreecallandmobile phonecall.Pressthe[5/]buttonduringcall. Answering a call Answeringacall Youcanansweranincomingcallbypressingthe[5/]
button. Pressthe[6/]buttontorejectanincomingcall. Whatisaudiostreaming?
Audiostreamingisatechniquefortransferringaudio datasuchthatitcanbeprocessedasasteadyand continuousstream.Userscanstreammusicfromtheir externalaudioplayertotheirvehiclestereowirelessly andlistentothetracksthroughthevehiclesspeakers. Pleaseconsultyournearestdealerformoreinformation ontheproductofwirelessaudiostreamingtransmitter offered. Pleaseavoidoperatingyourconnectedmobilephone whileaudiostreamingasthismaycausenoiseor soundchoppyonthesongplayback. Audiostreamingmayormaynotresumeafter telephoneinterruptasthisisdependentonmobile phone. ThesystemwillalwaysreturntoRadiomodeifaudio streamingisdisconnected. Note:
BesuretoreadthechapterPairingbefore proceeding. Playback/Pause TopauseandresumePlaybackpushbutton[1>]. Next/PreviousTrack. Toselectthenext/previoustrackpushthe[<</>>]
Toselectthenext/previoustrackpushthe[
]
button.
/
Note:
PlayingorderwilldependonBluetoothaudio player.Whenthe[<</>>]buttonispressed,some A2DP devices will restart the current track A2DPdeviceswillrestartthecurrenttrack dependsonthedurationofplayback. Duringmusicstreamingplayback,A2DPandHFP willbeshownonthedisplay.WhenA2DPdeviceis disconnected,DISCONNwillbeshownonthe displaySomeBluetoothaudioplayersmaynot haveplay/pausesynchronizedwiththisunit. Pleasemakesurebothdeviceandmainunitarein thesameplay/pausestatusinBTMUSICmode. Dimming Dimming 10 DisplayandButtonDimming Brightnessadjustment ManualMode Thisradioallowsmanualorautomaticdimming. Select DIMMING in the settings menu and Select DIMMING inthesettingsmenuand selectoneofthefollowingoptions:
SelectOFFtodisableDimming SelectManualdimmingwhentheradioisnot connectedtothevehiclesignitionpin. SelectAutomaticdimmingwhentheRadiois connectedcorrecttothevehiclesignitionpin. Toadjustyourfavouritebrightnesssettingfor display andbuttonbrightnessselectmanual mode. SelectManualdimmingtoadjustBrightnessofDisplay and Buttons andButtons ChangebetweenDayandNightModebyselecting DIMDAY or DIMNIGHT DIMDAY or DIMNIGHT AutomaticMode Inautomaticmodethedisplaywillchange automaticallybetweendayandnightmodewhenthe radioiscorrectconnectedtothevehiclesillumination pin. g y y DAY/NightSelection SelectDIMMANandchangebetweendaymode andnightmodebyselectingDIMDAYor DIMNIGHT NightBrightnessadjustmentofdisplayand Buttons ToadjustNightBrightnessofthedisplayand buttonsselectDIMNIGHT. ThenselectLCDMenuandadjustthebrightness of the Display accordingly oftheDisplayaccordingly. ThenselectKeyMenuandadjustthebrightness oftheButtonsaccordingly. DayBrightnessadjustmentofdisplayandButtons ToadjustDayBrightnessofthedisplayand buttonsselectDIMDAY. ThenselectLCDMenuandadjustthebrightness oftheDisplayaccordingly. ThenselectKeyMenuandadjustthebrightness oftheButtonsaccordingly System Setting Item List SystemSettingItemList 11 Tunersource Radioregion:Europe DABsource AUX/USB/BT(A2DP)source System Setting Item List SystemSettingItemList 12 Tunersource DABsource AUX/USB/BT(A2DP)source Radioregion:Asia/ Japan/NAfrica/USA System Setting SystemSetting 13 AM/FMTunerOptions DABTunerOptions DimmingOptions TA Enable /Disable automatic switching to FMtuner Enable/DisableautomaticswitchingtoFMtuner modeincaseofincomingTrafficannouncements. TAReturn SwitchbacktimeinthecasethatAnnouncement Signalcannotbedetectedanymore. AF Enable/Disableautomaticselectionofbest audiblefrequencyinFMTunerMode(RDS). REG Enable/Disableautomaticselectionofbetter audiblefrequenciesthatbroadcastdifferent regionalcontent. CT AutomaticsynchronizationofClockwithtime receivedviaRDSSignal. DX/LO SearchLevelofAM/FMTuner. ST/Mono SelectionofStereoorMonooutputofFM/AM tuner AERA SEL AERASEL ToadjusttheAM/FMtunertoyourregion. y DABFMLINK Enable /Disable automatic switching to FM tuner Enable/DisableautomaticswitchingtoFMtuner whenDABSignaldrops. DABLBND Enable/DisableLBandDecoding DABANT SelectionofActiveorPassiveantennais connected. DLSSCROLL EnabledisplayofArtistandSong BluetoothOptions SCROLL ON:DisplayID3taginformationcyclic:Track FolderFileAlbumTitleArtistTrack OFF:DisplayTrack MICSEL UseofintegratedMicrophoneinfrontpanelor externalMicrophoneconnectedbyrearconnector AUTO CON AUTOCON Todisable/enableBluetoothconnection SteeringWheelControlOptions SWRCTYPE SelectionofSteeringWheelcontroltype
(Resistance/PWM) SWRCSET Toenable/disablesteeringwheelcontrol g ode (O , DIMMING ToSelectDimmingMode(OFF,Manual,automatic) o Se ect a ua , auto at c) LCDMenu ToAdjustDisplaybrightness KEYMenu ToadjustButtonbrightness DIMMAN ToswitchbetweenDAYandNightMode Others MW Toenable/disableMWReception LW LW Toenable/disableLWReception BEEP Toenable/disableconfirmationsignal Logic Toenable/disableignitionlogic Clock Toadjusthoursandminutes d 12/24H Toselect12/24hClockformat h d Electrical Connections ElectricalConnections WiringDiagram DABSMBconnector AM/FMISOconnector 14 Electrical Connections ElectricalConnections WiringDiagram DABSMBconnector AM/FMISOconnector 14 T Troubleshooting bl h ti 15 The following checklist can help you solve some problems which you may encounter when using the unit. Before consulting it, check the connections and follow the instructions in the user manual. Do not use the unit in abnormal condition, for example without sound, or with smoke or foul smell can cause fire or electric shock, immediately stop using it and call the store where you purchased it. Problem General The unit will not switch on. No sound The unit or screen does not work normally. Mode TUNER Unable to receive stations. Poor quality reception of radio station. Mode USB Unable to insert USB device The USB device cannot be read. Possible cause Solution vehicle ignition is not on. Cable is not properly connected. Fuse is burnt. Volume is set at minimum or the mute function is on. The unit system is unstable. Turn your vehicle key in the ignition. Check cable connection. R l it Replace fuse with a new fuse of the same capacity. Check the volume or switch the mute function off. Press the RESET button. f th ith f f The antenna is not connected properly. Connect the antenna properly. The antenna is not fully extended or it is broken. Fully extend the antenna and if broken, replace it with a new one. The USB device has been inserted the wrong way round. Insert it the other way around. NTFS format is not supported. Check that the file system is in FAT or FAT32 format. Due to different formats, some models of storage devices or MP3 players may not be read. Specifications Specifications 16 AM/FMtuner Refer toAM/FMtunertable Refer toAM/FMtunertable USBCharging Maximum power ouput: 0.5A @5V 17 FCC FCC FCCSTATEMENT This device complies with Part 15 of theFCC Rules. Operation is subject tothefollowingtwo conditions:
di i television reception, which can be determined by turning the equipment offand on, the useris encouraged to try to correct the interferenceby oneormoreof thefollowingmeasures:
Reorientorrelocatethereceivingantenna.
(1)This device may not cause harmful interference. Increasetheseparationbetweenthe equipmentandreceiver
(2)This device must accept any interference received, including interference thatmaycause undesired operation undesiredoperation. Connect theequipment into an outlet on a circuit different from thatto which the receiveris connected connected. Consultthedealeroranexperiencedradio/TV technicianfor help. FCCRadiationExposureStatement ThisequipmentcomplieswithFCCradiationexposure limits setforthfor an uncontrolledenvironment. This equipment should beinstalled and operated with minimum distance 20cmbetweentheradiator&
yourbody.
(3)Changes or modifications not expressly approvedbythepartyresponsiblefor compliancecouldvoidtheuser'sauthority to operatetheequipment. NOTE:
NOTE:
This equipment has been tested and found to comply with the limits for a ClassB digital device, pursuant to Part15 of theFCC Rules.These limits are designed toprovide reasonable protection againstharmful interferenceinaresidentialinstallation. This equipment generatesuses and can radiateradiofrequencyenergyand,ifnot installedandusedinaccordancewiththe instructions,may cause harmful interferenceto radio communications. However, there isno guarantee that interference will not occurin a particular installation. Ifthis equipmentdoes cause harmful interference to radio or 18
1 | Internal Photos | Internal Photos | 1.19 MiB | July 04 2017 / September 04 2017 |
Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Page 47 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Antenna Page 48 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Page 49 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Page 50 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 END OF REPORT Page 51 of 51
1 | External Photos | External Photos | 659.17 KiB | July 04 2017 / September 04 2017 |
Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 15. Photos of the EUT Page 44 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Page 45 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Page 46 of 51
1 | Label | ID Label/Location Info | 1016.56 KiB | July 04 2017 / September 04 2017 |
A B C D E F 1 2 3 4 5 V00 6 7 8 90.00 mm MP3/USB PLAYER WITH FM/MW/LW TUNER MODEL NO.:TRD7412UB-OR DO NOT connect any speaker wires to the metal body or chassis of the vehicle.Do NOT connect the speaker common(-)Wires to each other. Connect each speaker wire directly to each speaker terminal.All speaker common(-)wires must remain floating. NOTE No Function No Function Telephone Mute Low Ignition Antenna remote ILLumination Battery +
Power Ground NO. A1 A2 A3 A4 A5 A6 A7 A8 C4 SWRC GND C6 SWRC+
NOTE Rear R+
Rear R-
Front R+
Front R-
Front L+
Front L-
Rear L+
Rear L-
NO. B1 B2 B3 B4 B5 B6 B7 B8 D1 MIC-
D2 MIC+
m m 0 0
. 5 5 A.N: 2910000430600 FCC ID: Y7O-TRD7412UB-OR 10R-05 3805 P/N:127072001192 19 0 x 5 5 m m 28 0 g() 3 4 1 2 3 C R B 4 1 1 4 U D 2 0 1 7 . 2 . 6 2 0 1 7 . 2 . 6 2 0 1 7 . 2 . 6 80g 1 2 7 0 7 2 0 0 1 1 9 2 6 CRB4114UD339B,MODEL LABEL 7 1 mm 1:1 A4 1 of 1 8 A B C D E F
1 | Authorization | Cover Letter(s) | 13.79 KiB | July 04 2017 / September 04 2017 |
Continental Automotive GmbH DATE : 2017-1-16 Nemko Canada Inc 303 River Road Ottawa, Ontario, Canada K1V 1H2 Attn: Director of Certification Authority to Act as Agent On our behalf, I appoint below company and person:
Name Position Company Name Dongguan Dongdian Testing Service Co.,Ltd. Address Kevin Feng Manager 17, Zongbu Road 2, Songshan Lake Sci&Tech, Industry Park, Dongguan City, Guangdong Province, China, 523808 Tel: +86-0769-22891499 fax:+86-0769-22895596 Kevinfeng@dgieie.com Tel / Fax E-Mail to act as our agent in the preparation of this application for equipment certification. I certify that submitted documents properly describe the device or system for which equipment certification is sought. I also certify that each unit manufactured, imported or marketed, as defined in the Federal Communications Commissions regulations will have affixed to it a label identical to that submitted for approval with this application. For instances where our authorized agent signs the application for certification on our behalf, I acknowledge that all responsibility for complying with the terms and conditions for certification, as specified by Nemko Canada Inc, still resides with:
Applicant name Continental Automotive GmbH Address Yours sincerely, Philipsstrasse 1, 35576 Wetzlar, Germany Signatory Marc Goldbach Name Company Name Continental Automotive GmbH Address Tel / Fax E-Mail Philipsstrasse 1, 35576 Wetzlar, Germany
+49-6441-370 9290/+49-6441-37013-9290 Marc.Goldbach@continental-corporation.com
1 | Confidentiality | Cover Letter(s) | 35.27 KiB | July 04 2017 / September 04 2017 |
Continental Automotive GmbH DATE : 2017-1-16 Equipment Autorisation Division Federal Communications Commission 7435 Oakland Mills Road Columbia, MD 21046 FCC ID: Y7O-TRD7412UB-OR Product Name: Car Audio Request for Confidentiality Pursuant to Sections 0.457 and 0.459 of the commissions rules, we hereby request that the following documents be held confidential:
Exhibit Type Schematics Block Diagrams Operational Description These materials contain trade secrets and proprietary information and are not customarily released to the public. The public disclosure of this information might be harmful to the company and provide unjustified benefits to our competitors. Yours sincerely, Description All circuitry of devices and component values Details of device showing oscillators Description of the circuit functions frequency of all the Signatory Marc Goldbach Name Company Name Continental Automotive GmbH Address Tel / Fax E-Mail Philipsstrasse 1, 35576 Wetzlar, Germany
+49-6441-370 9290/+49-6441-37013-9290 Marc.Goldbach@continental-corporation.com
1 | Declaration Letter | Cover Letter(s) | 59.60 KiB | July 04 2017 / September 04 2017 |
Continental Automotive GmbH Declaration of difference Date: 2017-4-1 To Whom It May Concern:
The product: Car Audio, Model No.: TRD7412UB-OR, TRD712UB-BU, TRD7412UB-
OR/CAT, All models are electrically identical, only the appearance, color, trade name and model No. are different. Yours sincerely, Signatory Marc Goldbach Name Company Name Continental Automotive GmbH Address Tel / Fax E-Mail Philipsstrasse 1, 35576 Wetzlar, Germany
+49-6441-370 9290/+49-6441-37013-9290 Marc.Goldbach@continental-corporation.com
1 | RF Exposure | RF Exposure Info | 28.36 KiB | July 04 2017 / September 04 2017 |
RF Exposure evaluation According to 447498 D01 General RF Exposure Guidance v05 The 1-g and 10-g SAR test exclusion thresholds for 100 MHz to 6 GHz at test separation distances 50 mm are determined by:
[(max. power of channel, including tune-up tolerance, mW)/(min. test separation distance, mm)] [f(GHz)] 3.0 for 1-g SAR and 7.5 for 10-g extremity SAR, where:
f(GHz) is the RF channel transmit frequency in GHz Power and distance are rounded to the nearest mW and mm before calculation The result is rounded to one decimal place for comparison Worse case is as below: [2480MHz, 5.20dBm (3.31mW) output power]
(3.31/5) [2.480(GHz)]= 1.04 <3.0 for 1-g SAR Then SAR evaluation is not required
1 | Test Report | Test Report | 2.78 MiB | July 04 2017 / September 04 2017 |
Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Report No.: DDT-R16Q1226-1E2 Issued Date: Apr. 1, 2017 FCC CERTIFICATION TEST REPORT FOR Applicant Address Equipment under Test Model No. Trade Mark FCC ID Manufacturer Address
: Continental Automotive GmbH
: Philipsstrasse 1, 35576 Wetzlar, Germany
: Car Audio
: TRD7412UB-OR, TRD712UB-BU, TRD7412UB-OR/CAT
: Continental, VDO, CAT
: Y7O-TRD7412UB-OR
: Huizhou Foryou General Electronics Co., Ltd.
: North Shangxia Road, Dongjiang Hi-tech Industry Park, Huizhou, Guangdong Province, 516005,P R China Issued By: Dongguan Dongdian Testing Service Co., Ltd. Add: No. 17, Zongbu Road 2, Songshan Lake Sci&Tech, Industry Park, Dongguan City, Guangdong Province, China, 523808 Tel: +86-0769-22891499 Http://www.dgddt.com Page 1 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 1. 2. 2.1. 2.2. 2.3. 2.4. 2.5. 2.6. 2.7. 2.8. 3. 4. 4.1. 4.2. 4.3. 4.4. 5. 5.1. 5.2. 5.3. 5.4. 5.5. 6. 6.1. 6.2. 6.3. 6.4. 6.5. 7. 7.1. 7.2. 7.3. 7.4. 7.5. 8. 8.1. TABLE OF CONTENTS Test report declares......................................................................................................................4 Summary of test results ............................................................................................................... 5 General test information .............................................................................................................. 6 Description of EUT ..................................................................................................................... 6 Accessories of EUT ..................................................................................................................... 6 Assistant equipment used for test ................................................................................................ 6 Block diagram of EUT configuration for test ............................................................................. 6 Deviations of test standard .......................................................................................................... 7 Test environment conditions ....................................................................................................... 7 Test laboratory ............................................................................................................................. 7 Measurement uncertainty ............................................................................................................ 8 Equipment used during test ......................................................................................................... 9 Maximum Peak Output Power .................................................................................................. 10 Block diagram of test setup ....................................................................................................... 10 Limits ........................................................................................................................................ 10 Test Procedure ........................................................................................................................... 10 Test Result ................................................................................................................................. 10 20dB Bandwidth and 99% Bandwidth ...................................................................................... 11 Block diagram of test setup ....................................................................................................... 11 Limits ........................................................................................................................................ 11 Test Procedure ........................................................................................................................... 11 Test Result ................................................................................................................................. 11 Original test data ....................................................................................................................... 12 Carrier Frequency Separation .................................................................................................... 14 Block diagram of test setup ....................................................................................................... 14 Limits ........................................................................................................................................ 14 Test Procedure ........................................................................................................................... 14 Test Result ................................................................................................................................. 14 Original test data ....................................................................................................................... 14 Number Of Hopping Channel ................................................................................................... 15 Block diagram of test setup ....................................................................................................... 15 Limits ........................................................................................................................................ 15 Test Procedure ........................................................................................................................... 15 Test Result ................................................................................................................................. 15 Original test data ....................................................................................................................... 15 Dwell Time ................................................................................................................................ 17 Block diagram of test setup ....................................................................................................... 17 Page 2 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 8.2. 8.3. 8.4. 8.5. 9. 9.1. 9.2. 9.3. 9.4. 10. 10.1. 10.2. 10.3. 10.4. 11. 11.1. 11.2. 11.3. 11.4. 12. 12.1. 12.2. 12.3. 12.4. 13. 13.1. 13.2. 14. 15. Limits ........................................................................................................................................ 17 Test Procedure ........................................................................................................................... 17 Test Result ................................................................................................................................. 17 Original test data ....................................................................................................................... 17 Radiated emission ..................................................................................................................... 20 Block diagram of test setup ....................................................................................................... 20 Limit .......................................................................................................................................... 21 Test Procedure ........................................................................................................................... 22 Test result .................................................................................................................................. 23 Band Edge Compliance (radiated method) ............................................................................... 27 Block diagram of test setup ....................................................................................................... 27 Limit .......................................................................................................................................... 27 Test Procedure ........................................................................................................................... 27 Test result .................................................................................................................................. 27 Band Edge Compliance (conducted method) ............................................................................ 36 Block diagram of test setup ....................................................................................................... 36 Limit .......................................................................................................................................... 36 Test result .................................................................................................................................. 36 Original test data ....................................................................................................................... 36 Power Line Conducted Emission .............................................................................................. 40 Block diagram of test setup ....................................................................................................... 40 Power Line Conducted Emission Limits(Class B) .................................................................... 40 Test Procedure ........................................................................................................................... 40 Test Result ................................................................................................................................. 41 Antenna Requirements .............................................................................................................. 42 Limit .......................................................................................................................................... 42 Result ......................................................................................................................................... 42 Test setup photograph ............................................................................................................... 43 Photos of the EUT ..................................................................................................................... 44 Page 3 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 TEST REPORT DECLARE Applicant Address Equipment under Test Model No. Trade Mark Manufacturer Address
: Continental Automotive GmbH
: Philipsstrasse 1, 35576 Wetzlar, Germany
: Car Audio
: TRD7412UB-OR, TRD712UB-BU, TRD7412UB-OR/CAT
: Continental, VDO, CAT
: Huizhou Foryou General Electronics Co., Ltd.
: North Shangxia Road, Dongjiang Hi-tech Industry Park, Huizhou, Guangdong Province, 516005,P R China Test Standard Used:
CFR47 FCC Part 15: Subpart C Section 15.247; CFR47 FCC Part 15: Subpart C Section 15.207;
CFR47 FCC Part 15: Subpart C Section 15.209 Test procedure used:
ANSI C63.10:2013, FCC KDB Publication 447498 D01 v06. We Declare:
The equipment described above is tested by Dongguan Dongdian Testing Service Co., Ltd and in the configuration tested the equipment complied with the standards specified above. The test results are contained in this test report and Dongguan Dongdian Testing Service Co., Ltd is assumed of full responsibility for the accuracy and completeness of these tests. After test and evaluation, our opinion is that the equipment provided for test compliance with the requirement of the above FCC standards. Report No:
Date of Receipt: Jan. 9, 2017 Jan. 9, 2017-Jan. 11, 2017 DDT-R16Q1226-1E2 Date of Test:
Prepared By: Approved By:
________________ _____________________ Leo Liu/Engineer Kevin Feng/EMC Manager Note: This report applies to above tested sample only. This report shall not be reproduced in parts without written approval of Dongguan Dongdian Testing Service Co., Ltd. Page 4 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 PASS PASS PASS PASS PASS PASS PASS N/A PASS Standard Results 1. Summary of test results Description of Test Item Maximum Peak Output Power 20dB Bandwidth and 99% Bandwidth Carrier Frequency Separation Number Of Hopping Channel Dwell Time Radiated Emission Band Edge Compliance FCC Part 15: 15.247(b)(1) ANSI C63.10:2013 FCC Part 15: 15.215 ANSI C63.10:2013 FCC Part 15: 15.247(a)(1) ANSI C63.10:2013 FCC Part 15: 15.247(a)(1)(iii) ANSI C63.10:2013 FCC Part 15: 15.247(a)(1)(iii) ANSI C63.10:2013 FCC Part 15: 15.209 FCC Part 15: 15.247(d) ANSI C63.10:2013 FCC Part 15: 15.247(d) ANSI C63.10:2013 Power Line Conducted Emissions FCC Part 15: 15.207 ANSI C63.10:2013 Antenna requirement FCC Part 15: 15.203 Note: N/A is an abbreviation for Not Applicable. This product can not be connected into public power supply. Page 5 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 2. General test information 2.1. Description of EUT
: Car Audio
: TRD7412UB-OR, TRD712UB-BU, TRD7412UB-OR/CAT
: All models are electrically identical, only the appearance, color, trade name and model No. are different. EUT* Name Model Number Difference of Model EUT function description : Please reference user manual of this device Power supply Radio Specification Operation frequency Modulation Modulation Types Equipment type Data rate Antenna Type Sample Type
: DC 12V
: Bluetooth V2.1+EDR
: 2402MHz -2480MHz
: GFSK, /4 QPSK, 8-DPSK
: Frequency Hopping Spread Spectrum (FHSS) modulation.
: Adaptive frequency hopping equipment.
: 1Mbps, 2Mbps, 3Mbps
: Integrated antenna, maximum PK gain: 0 dBi
: Series production Note: EUT is the ab. of equipment under test. 2.2. Accessories of EUT Description of Accessories N/A Manufacturer N/A Model number or Type N/A 2.3. Assistant equipment used for test Description of Assistant equipment N/A Manufacturer N/A Model number or Type N/A 2.4. Block diagram of EUT configuration for test Serial No. N/A EMC Compliance N/A Other N/A Other N/A EUT Test software: Bluesuite 2.6.0 The test software was used to control EUT work in Continuous TX mode, and select test channel, wireless mode as blow table. Page 6 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Tested mode, channel, information Mode Channel GFSK hopping on Tx Mode
/4 QPSK Hopping on TX mode 8-DPSK hopping on Tx Mode GFSK hopping off Tx Mode
/4 QPSK hopping off Tx Mode 8-DPSK hopping off Tx Mode CH0 to CH78 CH0 to CH78 CH0 to CH78 CH0 CH39 CH78 CH0 CH39 CH78 CH0 CH39 CH78 Frequency
(MHz) 2402 to 2480 2402 to 2480 2402 to 2480 2402 2441 2480 2402 2441 2480 2402 2441 2480 Note: For /4 QPSK its same modulation type with 8-DPSK, and based exploratory test, there is no significant difference of that two types test result, so except output power, all other items final test were only performed with the worse case 8-DPSK and GFSK. 2.5. Deviations of test standard No Deviation. 2.6. Test environment conditions During the measurement the environmental conditions were within the listed ranges:
21-25 40-75%
86-106kPa Temperature range:
Humidity range:
Pressure range:
2.7. Test laboratory Dongguan Dongdian Testing Service Co., Ltd Add: No. 17, Zongbu Road 2, Songshan Lake Sci&Tech, Industry Park, Dongguan City, Guangdong Province, China, 523808 Tel: +86-0769-22891499 http://www.dgddt.com FCC Registration Number: 270092 Industry Canada site registration number: 10288A-1 Page 7 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 2.8. Measurement uncertainty Test Item Bandwidth Peak Output Power(Conducted)( Spectrum analyzer) Uncertainty 1.1%
0.86dB(10 MHz f < 3.6GHz);
1.38dB(3.6GHz f < 8GHz) Peak Output Power(Conducted)(Power Sensor) 0.74dB Power Spectral Density Conducted spurious emissions Uncertainty for radio frequency (RBW<20KHz) Temperature Humidity Uncertainty for Radiation Emission test
(30MHz-1GHz) Uncertainty for Radiation Emission test
(1GHz-18GHz) 0.74dB(10 MHz f < 3.6GHz);
1.38dB(3.6GHz f < 8GHz) 0.86dB(10 MHz f < 3.6GHz);
1.40dB(3.6GHz f < 8GHz) 1.66dB(8GHz f < 22GHz) 310-8 0.4 2%
4.70 dB (Antenna Polarize: V) 4.84 dB (Antenna Polarize: H) 4.10dB(1-6GHz) 4.40dB (6GHz-18Gz) Uncertainty for Power line conduction emission test 3.32dB (150KHz-30MHz) Note: This uncertainty represents an expanded uncertainty expressed at approximately the 95%
confidence level using a coverage factor of k=2. Page 8 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Manufacturer Model No. Serial No. Last Cal. Cal. Interval JS Tonscend 3. Equipment used during test Equipment RF Connected Test Spectrum analyzer R&S Vertor Signal Generator R&S R&S RF Signal Generator Agilent Power Sensor Agilent Power Sensor DC Power Source MATRIS Mini-Circuits Attenuator Micable RF Cable Test Software JS Tonscend USB Data acquisition Agilent Auto control Unit Radiated Emission Test EMI Test Receiver Spectrum analyzer Trilog Broadband Antenna Active Loop antenna Double Ridged Horn Antenna Pre-amplifier RF Cable RF Cable MI Cable Test software Power Line Conducted Emissions Test Test Receiver LISN 1 LISN 2 Pulse Limiter CE Cable 1 Test software R&S R&S R&S R&S HUBSER Audix A.H. HUBSER HUBSER HUBSER Audix Schwarzbeck Schwarzbeck R&S R&S R&S FSU26 SMBV100A SMR20 U2021XA U2021XA MPS-3005L-3 D813058W BW-S10W2 C10-01-01-1 JS1120-2 U2531A JS0806-2 1166.1660.26 2016/10/24 1Year 1407.6004K02 2016/10/24 1Year 1104.0002.20 2016/10/24 1Year MY55150010 2016/04/18 1Year MY55150011 2016/04/19 1Year 2016/10/24 1Year 2016/08/18 1Year 101109 2016/08/18 1Year 100309 N/A Ver.2.5 TW55043503 N/A 158060010 N/A N/A N/A N/A ESU8 FSU26 100316 2016/10/24 1Year 1166.1660.26 2016/10/24 1Year VULB9163 FMZB-1519 HF907 9163-462 1519-038 100276 360 PAM-0118 W11.03 CP-X2 CP-X1 W12.02 C10-01-01-1M 1091629 E3 V 6.11111b ESU8 ENV216 ESH2-Z5 ESH3-Z2 ESU8/RF2 E3 100316 101109 100309 101242 W10.01 V 6.11111b 2016/05/30 1 Year 2016/10/24 1 Year 2016/10/31 1 Year 2016/08/18 1 Year 2016/10/24 1Year 2016/10/24 1 Year 2016/10/24 1 Year
/
/
2016/10/24 1 Year 2016/10/24 1 Year 2016/10/24 1 Year 2016/10/24 1 Year 2016/10/24 1 Year
/
/
Page 9 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 4. Maximum Peak Output Power 4.1. Block diagram of test setup 4.2. Limits For frequency hopping systems operating in the 2400-2483.5 MHz band employing at least 75 non-overlapping hopping channels, and all frequency hopping systems in the 5725-5850 MHz band: 1 watt. For all other frequency hopping systems in the 2400-2483.5 MHz band: 0.125 watts, the e.i.r.p shall not exceed 4W. 4.3. Test Procedure
(1) Connect EUTs antenna output to spectrum analyzer by RF cable.
(2) Measure the maximum output power of EUT by spectrum analyzer with PK detector and RBW=2MHz(above 20dB bandwidth of measured signal), VBW=3MHz Note: The attenuator loss was inputted into spectrum analyzer as amplitude offset. 4.4. Test Result Mode GFSK 8-DPSK Freq (MHz) Result (dBm) Limit (dBm) Conclusion 2402 2441 2480 2402 2441 2480 3.540 4.420 4.860 3.920 4.600 5.200 21 21 21 21 21 21 PASS PASS PASS PASS PASS PASS Page 10 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 5. 20dB Bandwidth and 99% Bandwidth 5.1. Block diagram of test setup Same as scetion 4.1 5.2. Limits Intentional radiators operating under the alternative provisions to the general emission limits, as contained in 15.217 through 15.257 and in Subpart E of this part, must be designed to ensure that the 20 dB bandwidth of the emission, or whatever bandwidth may otherwise be specified in the specific rule section under which the equipment operates, is contained within the frequency band designated in the rule section under which the equipment is operated. 5.3. Test Procedure
(1) Connect EUTs antenna output to spectrum analyzer by RF cable.
(2) The bandwidth of the fundamental frequency was measured by spectrum analyzer with 30 kHz RBW and 100 kHz VBW. The 20dB bandwidth is defined as the total spectrum the power of which is higher than peak power minus 20dB. 5.4. Test Result Mode GFSK 8-DPSK Freq
(MHz) 2402 2441 2480 2402 2441 2480 20dB bandwidth Result (MHz) 99% bandwidth Result (MHz) Conclusion 1.122 1.134 1.126 1.358 1.358 1.366 0.980 0.990 0.988 1.204 1.204 1.206 PASS PASS PASS PASS PASS PASS Page 11 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 5.5. Original test data Graphs GFSK/LCH GFSK/MCH GFSK/HCH Page 12 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 8DPSK/LCH 8DPSK/MCH 8DPSK/HCH Page 13 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 6. Carrier Frequency Separation 6.1. Block diagram of test setup Same as scetion 4.1 6.2. Limits Frequency hopping systems shall have hopping channel carrier frequencies separated by a minimum of 25 kHz or the 20 dB bandwidth of the hopping channel, whichever is greater. Alternatively, frequency hopping systems operating in the 2400-2483.5 MHz band may have hopping channel carrier frequencies that are separated by 25 kHz or two-thirds of the 20 dB bandwidth of the hopping channel, whichever is greater, provided the systems operate with an output power no greater than 125 mW. 6.3. Test Procedure
(1) Connect EUTs antenna output to spectrum analyzer by RF cable.
(2) The carrier frequency was measured by spectrum analyzer with 100 KHz RBW and 300 KHz VBW. 6.4. Test Result Mode GFSK 8-DPSK Channel separation
(MHz) Limit (MHz) 2/3 of 20dB bandwidth 1.002 1.002 two-thirds of the 20 dB Bandwidth Of The Hopping Channel two-thirds of the 20 dB Bandwidth Of The Hopping Channel Conclusion PASS PASS 6.5. Original test data GFSK Mode 8-DPSK Mode Page 14 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 7. Number Of Hopping Channel 7.1. Block diagram of test setup Same as scetion 4.1 7.2. Limits Frequency hopping systems in the 2400-2483.5 MHz band shall use at least 15 channels. 7.3. Test Procedure
(1) Connect EUTs antenna output to spectrum analyzer by RF cable.
(2) The number of hopping channel was measured by spectrum analyzer with 100 kHz RBW and300KHz VBW. 7.4. Test Result Mode GFSK 8-DPSK Number of hopping channel 79 79 Limit
>15
>15 Conclusion PASS PASS 7.5. Original test data Graphs GFSK/Hop Page 15 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 8DPSK/Hop Page 16 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 8. Dwell Time 8.1. Block diagram of test setup Same as scetion 4.1 8.2. Limits The average time of occupancy on any channel shall not be greater than 0.4 seconds within a period of 0.4 seconds multiplied by the number of hopping channels employed. 8.3. Test Procedure
(1) Connect EUTs antenna output to spectrum analyzer by RF cable.
(2) Measure the hopping number and on time of each pulse with spectrum analyzer in zero span set, and calculate dwell time with formula Dwell time = total hops *pulses on time. DH1 Packet permit maximum 1600 / 79 /2 = 10.12 hops per second in each channel (1 time slot RX, 1 time slot TX). So, total hops is 10.12 x 31.6 = 320. DH3 Packet permit maximum 1600 / 79 / 4 = 5.06 hops per second in each channel (3 time slots RX, 1 time slot TX). So, total hops is 5.06 x 31.6 = 160. DH5 Packet permit maximum 1600/ 79 / 6 = 3.37 hops per second in each channel (5 time slots RX, 1 time slot TX). So, total hops is 3.37 x 31.6 = 106.6. 3DH1 Packet permit maximum 1600 / 79 /2 = 10.12 hops per second in each channel (1 time slot RX, 1 time slot TX). So, total hops is 10.12 x 31.6 = 320. 3DH3 Packet permit maximum 1600 / 79 / 4 = 5.06 hops per second in each channel (3 time slots RX, 1 time slot TX). So, total hops is 5.06 x 31.6 = 160. 3DH5 Packet permit maximum 1600/ 79 / 6 = 3.37 hops per second in each channel (5 time slots RX, 1 time slot TX). So, total hops is 3.37 x 31.6 = 106.6. 8.4. Test Result Mode DH1 DH3 DH5 3-DH1 3-DH3 3-DH5 Pulses on time (ms) Total hops Dwell time (s) 0.39 1.65 2.9 0.4 1.66 2.91 320 160 106.7 320 160 106.7 0.125 0.264 0.309 0.128 0.266 0.31 Limit
<400ms
<400ms
<400ms
<400ms
<400ms
<400ms Conclusion PASS PASS PASS PASS PASS PASS Note: Dwell time = total hops *pulses on time. 8.5. Original test data Graphs Page 17 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 DH1 DH3 DH5 Page 18 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 3DH1 3DH3 3DH5 Page 19 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 9. Radiated emission 9.1. Block diagram of test setup In 3m Anechoic Chamber Test Setup Diagram for 9KHz-30MHz In 3m Anechoic Chamber Test Setup Diagram for below 1GHz In 3m Anechoic Chamber Test Setup Diagram for frequency above 1GHz Page 20 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Note: For harmonic emissions test a appropriate high pass filter was inserted in the input port of AMP. 9.2. Limit 9.2.1 FCC 15.205 Restricted frequency band 9.2.2 FCC 15.209 Limit. FREQUENCY MHz 0.009 ~ 0.490 0.490 ~ 1.705 1.705 ~ 30.0 30 ~ 88 88 ~ 216 216 ~ 960 960 ~ 1000 DISTANCE Meters 300 30 30 3 3 3 3 FIELD STRENGTHS LIMIT V/m dB(V)/m 2400/F(KHz) 24000/F(KHz) 67.6-20log(F) 87.6-20log(F) 30 100 150 200 500 29.54 40.0 43.5 46.0 54.0 Page 21 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Above 1000 3 74.0 dB(V)/m (Peak) 54.0 dB(V)/m (Average) Note: (1)The emission limits shown in the above table are based on measurements employing a CISPR QP detector except for the frequency bands 9-90KHz, 110-490KHz and above 1000MHz.Radiated emissions limits in these three bands are based on measurements employing an average detector.
(2) At frequencies below 30MHz, measurement may be performed at a distance closer then that specified, and the limit at closer measurement distance can be extrapolated by below formula:
Limit3m(dBuV/m)= Limit30m(dBuV/m) + 40Log(30m/3m) 9.2.3 Limit for this EUT All the emissions appearing within 15.205 restricted frequency bands shall not exceed the limits shown in 15.209, all the other emissions shall be at least 20dB below the fundamental emissions, or comply with 15.209 limits. 9.3. Test Procedure
(1) EUT was placed on a non-metallic table, 150 cm above the ground plane inside a semi-anechoic chamber.
(2) Test antenna was located 3m from the EUT on an adjustable mast, and the antenna used as below table. Test frequency range 9KHz-30MHz 30MHz-1GHz 1GHz-18GHz 18GHz-40GHz Test antenna used Active Loop antenna Trilog Broadband Antenna Double Ridged Horn Antenna(1GHz-18GHz) Horn Antenna(18GHz-40GHz) According ANSI C63.10:2013 clause 6.4.4.2 and 6,5.3, for measurements below 30 MHz, the loop antenna was positioned with its plane vertical from the EUT and rotated about its vertical axis for maximum response at each azimuth position around the EUT. And the loop antenna also be positioned with its plane horizontal at the specified distance from the EUT. The center of the loop is 1 m above the ground. for measurement above 30MHz, the Trilog Broadband Antenna or Horn Antenna was located 3m from EUT, Measurements were made with the antenna positioned in both the horizontal and vertical planes of Polarization, and the measurement antenna was varied from 1 m to 4 m. in height above the reference ground plane to obtain the maximum signal strength.
(3) Below pre-scan procedure was first performed in order to find prominent frequency spectrum radiated emissions from 9KHz to 25GHz:
(a) Scanning the peak frequency spectrum with the antenna specified in step (3), and the EUT was rotated 360 degree, the antenna height was varied from 1m to 4m(Except loop antenna, its fixed 1m above ground.)
(b) Change work frequency or channel of device if practicable.
(c) Change modulation type of device if practicable.
(d) Change power supply range from 85% to 115% of the rated supply voltage
(e) Rotated EUT though three orthogonal axes to determine the attitude of EUT arrangement produces Page 22 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 highest emissions. Spectrum frequency from 9KHz to 25GHz (tenth harmonic of fundamental frequency) was investigated, and no any obvious emission were detected from 18GHz to 25GHz, so below final test was performed with frequency range from 9KHz to 18GHz.
(4) For final emissions measurements at each frequency of interest, the EUT was rotated and the antenna height was varied between 1m and 4m in order to maximize the emission. Measurements in both horizontal and vertical polarities were made and the data was recorded. In order to find the maximum emission, the relative positions of equipments and all of the interface cables were changed according to ANSI C63.10 2013 on Radiated Emission test.
(5) The emissions from 9KHz to 1GHz were measured based on CISPR QP detector except for the frequency bands 9-90KHz, 110-490KHz, for emissions from 9KHz-90KHz,110KHz-490KHz and above 1GHz were measured based on average detector, for emissions above 1GHz, peak emissions also be measured and need comply with Peak limit.
(6) The emissions from 9KHz to 1GHz, QP or average values were measured with EMI receiver with below RBW. Frequency band 9KHz-150KHz 150KHz-30MHz 30MHz-1GHz RBW 200Hz 9KHz 120KHz
(7) For emissions above 1GHz, both Peak and Average level were measured with Spectrum Analyzer, and the RBW is set at 1MHz, VBW is set at 3MHz for Peak measure; RMS detector RBW 1MHz VBW 3MHz for Average measure(according ANSI C63.10:2013 clause 4.2.3.2.3 procedure for average measure).
(8) X axis, Y axis, Z axis are tested, and worse setup X axis is reported. 9.4. Test result PASS. (See below detailed test result) All the emissions except fundamental emission from 9 KHz to 25GHz were comply with 15.209 limits. Note1: According exploratory test no any obvious emission were detected from 9KHz to 30MHz and 18GHz to 25GHz, so the final test was performed with frequency range from 30MHz to 18GHz and recorded in below. Note2: For emissions below 1GHz, according exploratory explorer test, when change Tx mode and channel, have no distinct influence on emissions level, so for emissions below 1GHz, the final test was only performed with EUT working in GFSK, Tx 2441MHz mode. Note3: For emissions above 1GHz. If peak results comply with AV limit, AV Result is deemed to comply with AV limit. Page 23 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Radiated Emission test (below 1GHz) TR-4-E-009 Radiated Emission Test Result Test Site Test Date
: DDT 3m Chamber 1#
D:\2016 Report Data\16Q1226-1\FCC RF.EM6
: 2017-01-10 Tested By
: Sincere EUT : Car Audio Power Supply
: DC 12V Condition
:
Temp:24.5'C,Humi:55%, Press:100.1kPa Memo
:
Data: 1 Model Number
: TRD7412UB-OR Test Mode
: Tx mode Antenna/Distance
: 2016 VULB9163 1#/3m/VERTICAL Item
(Mark) Result Level
(dBV/m) Freq.
(MHz) 58.41 96.10 175.04 245.09 625.08 948.76 Read Level
(dBV) 2.66 2.03 5.98 9.32 2.73 2.94 Antenna Factor
(dB/m) 11.70 11.69 8.90 12.30 19.40 22.82 Cable Loss dB 3.96 4.27 4.75 5.12 6.59 7.55 1 2 3 4 5 6 Note: 1. Result Level = Read Level + Antenna Factor + Cable loss. 2. If Peak Result complies with QP limit, QP Result is deemed to comply with QP limit. 3. Test setup: RBW: 120 kHz, VBW: 300 kHz, Sweep time: auto. 18.32 17.99 19.63 26.74 28.72 33.31 Limit Line
(dBV/m) 40.00 43.50 43.50 46.00 46.00 46.00 Over Limit
(dB)
-21.68
-25.51
-23.87
-19.26
-17.28
-12.69 Detector Polarization QP QP QP QP QP QP VERTICAL VERTICAL VERTICAL VERTICAL VERTICAL VERTICAL Page 24 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Test Site Test Date TR-4-E-009 Radiated Emission Test Result
: DDT 3m Chamber 1#
D:\2016 Report Data\16Q1226-1\FCC RF.EM6
: 2017-01-10 Tested By
: Sincere EUT : Car Audio Power Supply
: DC 12V Condition
:
Temp:24.5'C,Humi:55%, Press:100.1kPa Memo
:
Data: 2 Model Number
: TRD7412UB-OR Test Mode
: Tx mode Antenna/Distance
: 2016 VULB9163 1#/3m/HORIZONTAL Item
(Mark) Result Level
(dBV/m) Freq.
(MHz) 52.39 108.27 257.42 268.49 280.02 929.01 Read Level
(dBV) 3.12 2.44 7.95 7.48 7.33 3.67 Antenna Factor
(dB/m) 11.70 11.20 12.35 12.81 12.60 22.70 Cable Loss dB 3.91 4.35 5.17 5.23 5.28 7.50 1 2 3 4 5 6 Note: 1. Result Level = Read Level + Antenna Factor + Cable loss. 2. If Peak Result complies with QP limit, QP Result is deemed to comply with QP limit. 3. Test setup: RBW: 120 kHz, VBW: 300 kHz, Sweep time: auto. 18.73 17.99 25.47 25.52 25.21 33.87 Limit Line
(dBV/m) 40.00 43.50 46.00 46.00 46.00 46.00 Over Limit
(dB)
-21.27
-25.51
-20.53
-20.48
-20.79
-12.13 Detector Polarization QP QP QP QP QP QP HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL Page 25 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Margin
(dB) Detector type Polarization
-28.89
-25.53
-26.71
-25.53
-23.57
-21.08
-27.30
-27.51
-25.52
-24.27
-25.53
-24.48
-28.75
-26.92
-27.40
-26.51
-25.53
-21.91
-31.23
-29.07
-27.96
-27.33
-25.69
-24.74 Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak VERTICAL VERTICAL VERTICAL VERTICAL VERTICAL VERTICAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL VERTICAL VERTICAL VERTICAL VERTICAL VERTICAL VERTICAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL
(dBV/m) Result Level Freq
(MHz) PRM Factor
(dB) Read level
(dBV) Antenna Factor
(dB/m) 45.11 48.47 47.29 48.47 50.43 52.92 46.70 46.49 48.48 49.73 48.47 49.52 29.59 29.04 29.35 29.42 30.24 30.49 29.07 29.35 29.34 30.16 30.40 31.04 31.89 33.40 33.70 35.41 36.03 36.37 33.23 33.70 35.30 35.98 36.23 36.66 35.55 36.50 34.27 32.67 34.41 36.44 34.96 33.49 32.75 33.74 32.17 32.87 3471.00 4003.00 4990.00 6250.00 6789.00 7209.00 3940.00 4976.00 6180.00 6726.00 7041.00 7804.00 Radiated Emission test (above 1GHz) Cable Limit Loss
(dB
(dB) V/m) GFSK Tx mode 2402MHz 74.00 7.26 74.00 7.61 8.67 74.00 74.00 9.81 74.00 10.23 10.60 74.00 74.00 7.58 74.00 8.65 74.00 9.77 10.17 74.00 74.00 10.47 11.03 74.00 GFSK Tx mode 2441MHz 74.00 6.92 74.00 7.69 74.00 8.80 9.29 74.00 74.00 9.89 74.00 10.71 6.85 74.00 74.00 7.42 74.00 7.60 74.00 8.56 9.71 74.00 10.15 74.00 GFSK Tx mode 2480MHz 7.53 74.00 74.00 8.02 74.00 8.67 74.00 9.71 10.30 74.00 74.00 10.81 74.00 7.52 7.69 74.00 74.00 8.37 74.00 8.63 9.71 74.00 74.00 10.81 3142.00 4066.00 5109.00 5599.00 6411.00 7328.00 3065.00 3695.00 3989.00 4885.00 6047.00 6712.00 34.11 33.98 33.50 33.10 32.30 34.49 35.01 34.58 34.67 34.83 33.31 34.06 29.11 29.14 29.35 29.23 30.28 30.73 29.11 29.05 29.30 29.34 29.23 30.73 36.67 34.98 33.21 32.68 32.58 35.50 34.34 34.24 34.12 33.72 32.75 33.30 31.76 33.46 33.93 34.76 35.66 36.47 31.73 32.51 33.37 33.72 35.08 35.97 30.10 29.05 29.34 29.24 29.66 30.59 30.15 29.24 29.05 29.33 29.23 30.16 45.25 47.08 46.60 47.49 48.47 52.09 42.77 44.93 46.04 46.67 48.31 49.26 33.05 33.70 33.70 35.09 36.09 36.56 33.01 33.47 33.76 33.71 35.08 36.56 3877.00 4374.00 4997.00 6054.00 6859.00 7447.00 3863.00 4080.00 4710.00 4962.00 6047.00 7447.00 Result: Pass Note: 1.30MHz~18GHz: (Scan with GFSK, /4 QPSK, 8-DPSK, the worst case is GFSK Mode) 2. Result Level = Read Level + Antenna Factor + Cable loss - PRM Factor.
-28.42
-27.44
-27.48
-25.33
-25.59
-22.87
-27.57
-27.31
-26.50
-26.17
-25.13
-23.30 45.58 46.56 46.52 48.67 48.41 51.13 46.43 46.69 47.50 47.83 48.87 50.70 Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak Peak VERTICAL VERTICAL VERTICAL VERTICAL VERTICAL VERTICAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL HORIZONTAL Page 26 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 10. Band Edge Compliance (radiated method) 10.1. Block diagram of test setup 10.2. Limit All restriction band should comply with 15.209, other emission should be at least 20dB blow the fundamental. 10.3. Test Procedure Same with clause 9.3 except change investigated frequency range from 2310MHz to 2415MHz and 2475MHz to 2500MHz. Remark: All restriction band have been tested, and only the worse case is shown in report. 10.4. Test result PASS. (See below detailed test result) Remark: hopping on and hopping off mode all have been test, hopping off mode is worse and reported only. Page 27 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 TR-4-E-009 Radiated Emission Test Result Test Site
: DDT 3m Chamber D:\2016 Report Data\16Q1226-1\FCC RF.EM6 Test Date
: 2017-01-10 Tested By
: Sincere EUT : Car Audio Model Number
: TRD7412UB-OR Power Supply : DC12V Test Mode
: TX mode GFSK CH0 2402MHz Condition
:
Temp:24.5'C,Humi:55%, Press:100.1kPa Memo
:
Antenna/Distance
: 2016 HF907/3m/HORIZONTAL Data: 5 Item Freq.
(Mark) 1 2
(MHz) 2376.82 2390.00 Read Level
(dBV) 35.54 33.07 Antenna Factor
(dB/m) 29.72 29.78 PRM Factor dB 29.39 29.41 Cable Loss dB 6.01 6.01 Result Level
(dBV/m) 41.88 39.45 Limit Line
(dBV/m) 74.00 74.00 Over Limit
(dB)
-32.12
-34.55 Detector Polarization Peak Peak HORIZONTAL HORIZONTAL Note: 1. Result Level = Read Level + Antenna Factor + Cable loss - PRM Factor. 2. If Peak Result complies with AV limit, AV Result is deemed to comply with AV limit. 3. Test setup: RBW: 1 MHz, VBW: 3 MHz, Sweep time: auto. Page 28 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 TR-4-E-009 Radiated Emission Test Result Test Site
: DDT 3m Chamber D:\2016 Report Data\16Q1226-1\FCC RF.EM6 Test Date
: 2017-01-10 Tested By
: Sincere EUT : Car Audio Model Number
: TRD7412UB-OR Power Supply : DC12V Test Mode
: TX mode GFSK CH0 2402MHz Condition
:
Temp:24.5'C,Humi:55%, Press:100.1kPa Memo
:
Antenna/Distance
: 2016 HF907/3m/VERTICAL Data: 6 Item Freq.
(Mark) 1 2
(MHz) 2375.08 2390.02 Read Level
(dBV) 35.71 35.51 Antenna Factor
(dB/m) 29.72 29.78 PRM Factor dB 29.38 29.41 Cable Loss dB 5.98 6.01 Result Level
(dBV/m) 42.03 41.89 Limit Line
(dBV/m) 74.00 74.00 Over Limit
(dB)
-31.97
-32.11 Detector Polarization Peak Peak VERTICAL VERTICAL Note: 1. Result Level = Read Level + Antenna Factor + Cable loss - PRM Factor. 2. If Peak Result complies with AV limit, AV Result is deemed to comply with AV limit. 3. Test setup: RBW: 1 MHz, VBW: 3 MHz, Sweep time: auto. Page 29 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 TR-4-E-009 Radiated Emission Test Result Test Site
: DDT 3m Chamber D:\2016 Report Data\16Q1226-1\FCC RF.EM6 Test Date
: 2017-01-10 Tested By
: Sincere EUT : Car Audio Model Number
: TRD7412UB-OR Power Supply : DC12V Test Mode
: TX mode GFSK CH0 2480MHz Condition
:
Temp:24.5'C,Humi:55%, Press:100.1kPa Memo
:
Antenna/Distance
: 2016 HF907/3m/VERTICAL Data: 11 Item Freq.
(Mark) 1 2 3
(MHz) 2483.50 2488.80 2493.48 Read Level
(dBV) 34.41 37.35 38.12 Antenna Factor
(dB/m) 30.14 30.16 30.18 PRM Factor dB 29.71 29.71 29.73 Cable Loss dB 6.15 6.15 6.15 Result Level
(dBV/m) 40.99 43.95 44.72 Limit Line
(dBV/m) 74.00 74.00 74.00 Over Limit
(dB)
-33.01
-30.05
-29.28 Detector Polarization Peak Peak Peak VERTICAL VERTICAL VERTICAL Note: 1. Result Level = Read Level + Antenna Factor + Cable loss - PRM Factor. 2. If Peak Result complies with AV limit, AV Result is deemed to comply with AV limit. 3. Test setup: RBW: 1 MHz, VBW: 3 MHz, Sweep time: auto. Page 30 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 TR-4-E-009 Radiated Emission Test Result Test Site
: DDT 3m Chamber D:\2016 Report Data\16Q1226-1\FCC RF.EM6 Test Date
: 2017-01-10 Tested By
: Sincere EUT : Car Audio Model Number
: TRD7412UB-OR Power Supply : DC12V Test Mode
: TX mode GFSK CH0 2480MHz Condition
:
Temp:24.5'C,Humi:55%, Press:100.1kPa Memo
:
Antenna/Distance
: 2016 HF907/3m/HORIZONTAL Data: 12 Item Freq.
(Mark) 1 2 3
(MHz) 2483.50 2489.28 2493.93 Read Level
(dBV) 36.78 36.97 37.86 Antenna Factor
(dB/m) 30.14 30.16 30.18 PRM Factor dB 29.71 29.73 29.73 Cable Loss dB 6.15 6.15 6.15 Result Level
(dBV/m) 43.36 43.55 44.46 Limit Line
(dBV/m) 74.00 74.00 74.00 Over Limit
(dB)
-30.64
-30.45
-29.54 Detector Polarization Peak Peak Peak HORIZONTAL HORIZONTAL HORIZONTAL Note: 1. Result Level = Read Level + Antenna Factor + Cable loss - PRM Factor. 2. If Peak Result complies with AV limit, AV Result is deemed to comply with AV limit. 3. Test setup: RBW: 1 MHz, VBW: 3 MHz, Sweep time: auto. Page 31 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 TR-4-E-009 Radiated Emission Test Result Test Site
: DDT 3m Chamber D:\2016 Report Data\16Q1226-1\FCC RF.EM6 Test Date
: 2017-01-10 Tested By
: Sincere EUT : Car Audio Model Number
: TRD7412UB-OR Power Supply : DC12V Test Mode
: TX mode 8-DPSK CH0 2402MHz Condition
:
Temp:24.5'C,Humi:55%, Press:100.1kPa Memo
:
Antenna/Distance
: 2016 HF907/3m/VERTICAL Data: 15 Item Freq.
(Mark) 1 2
(MHz) 2375.08 2390.00 Read Level
(dBV) 35.73 34.07 Antenna Factor
(dB/m) 29.72 29.78 PRM Factor dB 29.38 29.41 Cable Loss dB 5.98 6.01 Result Level
(dBV/m) 42.05 40.45 Limit Line
(dBV/m) 74.00 74.00 Over Limit
(dB)
-31.95
-33.55 Detector Polarization Peak Peak VERTICAL VERTICAL Note: 1. Result Level = Read Level + Antenna Factor + Cable loss - PRM Factor. 2. If Peak Result complies with AV limit, AV Result is deemed to comply with AV limit. 3. Test setup: RBW: 1 MHz, VBW: 3 MHz, Sweep time: auto. Page 32 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 TR-4-E-009 Radiated Emission Test Result Test Site
: DDT 3m Chamber D:\2016 Report Data\16Q1226-1\FCC RF.EM6 Test Date
: 2017-01-10 Tested By
: Sincere EUT : Car Audio Model Number
: TRD7412UB-OR Power Supply : DC12V Test Mode
: TX mode 8-DPSK CH0 2402MHz Condition
:
Temp:24.5'C,Humi:55%, Press:100.1kPa Memo
:
Antenna/Distance
: 2016 HF907/3m/HORIZONTAL Data: 16 Item Freq.
(Mark) 1 2
(MHz) 2377.06 2390.02 Read Level
(dBV) 35.24 34.51 Antenna Factor
(dB/m) 29.73 29.78 PRM Factor dB 29.39 29.41 Cable Loss dB 6.01 6.01 Result Level
(dBV/m) 41.59 40.89 Limit Line
(dBV/m) 74.00 74.00 Over Limit
(dB)
-32.41
-33.11 Detector Polarization Peak Peak HORIZONTAL HORIZONTAL Note: 1. Result Level = Read Level + Antenna Factor + Cable loss - PRM Factor. 2. If Peak Result complies with AV limit, AV Result is deemed to comply with AV limit. 3. Test setup: RBW: 1 MHz, VBW: 3 MHz, Sweep time: auto. Page 33 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 TR-4-E-009 Radiated Emission Test Result Test Site
: DDT 3m Chamber D:\2016 Report Data\16Q1226-1\FCC RF.EM6 Test Date
: 2017-01-10 Tested By
: Sincere EUT : Car Audio Model Number
: TRD7412UB-OR Power Supply : DC12V Test Mode
: TX mode 8-DPSK CH0 2480MHz Condition
:
Temp:24.5'C,Humi:55%, Press:100.1kPa Memo
:
Antenna/Distance
: 2016 HF907/3m/HORIZONTAL Data: 21 Item Freq.
(Mark) 1 2
(MHz) 2483.50 2489.28 Read Level
(dBV) 36.19 37.25 Antenna Factor
(dB/m) 30.14 30.16 PRM Factor dB 29.71 29.73 Cable Loss dB 6.15 6.15 Result Level
(dBV/m) 42.77 43.83 Limit Line
(dBV/m) 74.00 74.00 Over Limit
(dB)
-31.23
-30.17 Detector Polarization Peak Peak HORIZONTAL HORIZONTAL Note: 1. Result Level = Read Level + Antenna Factor + Cable loss - PRM Factor. 2. If Peak Result complies with AV limit, AV Result is deemed to comply with AV limit. 3. Test setup: RBW: 1 MHz, VBW: 3 MHz, Sweep time: auto. Page 34 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 TR-4-E-009 Radiated Emission Test Result Test Site
: DDT 3m Chamber D:\2016 Report Data\16Q1226-1\FCC RF.EM6 Test Date
: 2017-01-10 Tested By
: Sincere EUT : Car Audio Model Number
: TRD7412UB-OR Power Supply : DC12V Test Mode
: TX mode 8-DPSK CH0 2480MHz Condition
:
Temp:24.5'C,Humi:55%, Press:100.1kPa Memo
:
Antenna/Distance
: 2016 HF907/3m/VERTICAL Data: 22 Item Freq.
(Mark) 1 2
(MHz) 2483.50 2489.15 Read Level
(dBV) 41.14 37.97 Antenna Factor
(dB/m) 30.14 30.16 PRM Factor dB 29.71 29.73 Cable Loss dB 6.15 6.15 Result Level
(dBV/m) 47.72 44.55 Limit Line
(dBV/m) 74.00 74.00 Over Limit
(dB)
-26.28
-29.45 Detector Polarization Peak Peak VERTICAL VERTICAL Note: 1. Result Level = Read Level + Antenna Factor + Cable loss - PRM Factor. 2. If Peak Result complies with AV limit, AV Result is deemed to comply with AV limit. 3. Test setup: RBW: 1 MHz, VBW: 3 MHz, Sweep time: auto. Page 35 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 11. Band Edge Compliance (conducted method) 11.1. Block diagram of test setup Same as scetion 4.1 11.2. Limit All restriction band should comply with 15.209, other emission should be at least 20dB blow the fundamental. 11.3. Test result Mode GFSK 8-DPSK 11.4. Original test data Freq (MHz) Hopping off 2402 Hopping off 2480 Hopping on Hopping off 2402 Hopping off 2480 Hopping on Graphs Conclusion PASS PASS PASS PASS PASS PASS GFSK/LCH/No Hop Page 36 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 GFSK/LCH/Hop GFSK/HCH/No Hop GFSK/HCH/Hop Page 37 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 8DPSK/LCH/No Hop 8DPSK/LCH/Hop 8DPSK/HCH/No Hop Page 38 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 8DPSK/HCH/Hop Page 39 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 12. Power Line Conducted Emission 12.1. Block diagram of test setup 12.2. Power Line Conducted Emission Limits(Class B) Frequency 150kHz 500kHz 5MHz
~
~
~
500kHz 5MHz 30MHz Quasi-Peak Level dB(V) 66 ~ 56*
56 60 Average Level dB(V) 56 ~ 46*
46 50 Note 1: * Decreasing linearly with logarithm of frequency. Note 2: The lower limit shall apply at the transition frequencies. 12.3. Test Procedure The EUT and Support equipment, if needed, were put placed on a non-metallic table, 80cm above the ground plane. Configuration EUT to simulate typical usage as described in clause 2.4 and test equipment as described in clause 10.2 of this report. All I/O cables were positioned to simulate typical actual usage as per ANSI C63.4. All support equipment power received from a second LISN. Emissions were measured on each current carrying line of the EUT using an EMI Test Receiver connected to the LISN powering the EUT. The Receiver scanned from 150 kHz to 30MHz for emissions in each of the test modes. During the above scans, the emissions were maximized by cable manipulation. The test mode(s) described in clause 2.4 were scanned during the preliminary test. After the preliminary scan, we found the test mode producing the highest emission level. Page 40 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 The EUT configuration and worse cable configuration of the above highest emission levels were recorded for reference of the final test. EUT and support equipment were set up on the test bench as per the configuration with highest emission level in the preliminary test. A scan was taken on both power lines, Neutral and Line, recording at least the six highest emissions. Emission frequency and amplitude were recorded into a computer in which correction factors were used to calculate the emission level and compare reading to the applicable limit. The test data of the worst-case condition(s) was recorded. The bandwidth of test receiver is set at 9 KHz. 12.4. Test Result Not Applicable Page 41 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 13. Antenna Requirements 13.1. Limit For intentional device, according to FCC 47 CFR Section 15.203, an intentional radiator shall be designed to ensure that no antenna other than that furnished by the responsible party shall be used with the device. And according to FCC 47 CFR Section 15.247 (b), if transmitting antennas of directional gain greater than 6dBi are used, the power shall be reduced by the amount in dB that the directional gain of the antenna exceeds 6dBi. 13.2. Result The antennas used for this product are integrated antenna and that no antenna other than that furnished by the responsible party shall be used with the device, the maximum peak gain of the transmit antenna is only 0 dBi. Page 42 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 14. Test setup photograph Page 43 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 15. Photos of the EUT Page 44 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Page 45 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Page 46 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Page 47 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Antenna Page 48 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Page 49 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 Page 50 of 51 Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 END OF REPORT Page 51 of 51
1 | Test Set Up Photos | Test Setup Photos | 163.74 KiB | July 04 2017 / September 04 2017 |
Dongguan Dongdian Testing Service Co., Ltd Report No.: DDT-R16Q1226-1E2 14. Test setup photograph Page 43 of 51
frequency | equipment class | purpose | ||
---|---|---|---|---|
1 | 2017-04-09 | 2402 ~ 2480 | DSS - Part 15 Spread Spectrum Transmitter | Original Equipment |
app s | Applicant Information | |||||
---|---|---|---|---|---|---|
1 | Effective |
2017-04-09
|
||||
1 | Applicant's complete, legal business name |
Continental Automotive GmbH
|
||||
1 | FCC Registration Number (FRN) |
0020532859
|
||||
1 | Physical Address |
Philipsstrasse 1
|
||||
1 |
Wetzlar, N/A
|
|||||
1 |
Germany
|
|||||
app s | TCB Information | |||||
1 | TCB Application Email Address |
s******@nemko.com
|
||||
1 | TCB Scope |
A4: UNII devices & low power transmitters using spread spectrum techniques
|
||||
app s | FCC ID | |||||
1 | Grantee Code |
Y7O
|
||||
1 | Equipment Product Code |
TRD7412UB-OR
|
||||
app s | Person at the applicant's address to receive grant or for contact | |||||
1 | Name |
M******** G****
|
||||
1 | Title |
Dr.
|
||||
1 | Telephone Number |
+49-6******** Extension:
|
||||
1 | Fax Number |
+49-6********
|
||||
1 |
M******@continental-corporation.com
|
|||||
app s | Technical Contact | |||||
n/a | ||||||
app s | Non Technical Contact | |||||
n/a | ||||||
app s | Confidentiality (long or short term) | |||||
1 | Does this application include a request for confidentiality for any portion(s) of the data contained in this application pursuant to 47 CFR § 0.459 of the Commission Rules?: | Yes | ||||
1 | Long-Term Confidentiality Does this application include a request for confidentiality for any portion(s) of the data contained in this application pursuant to 47 CFR § 0.459 of the Commission Rules?: | No | ||||
if no date is supplied, the release date will be set to 45 calendar days past the date of grant. | ||||||
app s | Cognitive Radio & Software Defined Radio, Class, etc | |||||
1 | Is this application for software defined/cognitive radio authorization? | No | ||||
1 | Equipment Class | DSS - Part 15 Spread Spectrum Transmitter | ||||
1 | Description of product as it is marketed: (NOTE: This text will appear below the equipment class on the grant) | Car Audio | ||||
1 | Related OET KnowledgeDataBase Inquiry: Is there a KDB inquiry associated with this application? | No | ||||
1 | Modular Equipment Type | Does not apply | ||||
1 | Purpose / Application is for | Original Equipment | ||||
1 | Composite Equipment: Is the equipment in this application a composite device subject to an additional equipment authorization? | No | ||||
1 | Related Equipment: Is the equipment in this application part of a system that operates with, or is marketed with, another device that requires an equipment authorization? | No | ||||
1 | Grant Comments | Output power listed is conducted. | ||||
1 | Is there an equipment authorization waiver associated with this application? | No | ||||
1 | If there is an equipment authorization waiver associated with this application, has the associated waiver been approved and all information uploaded? | No | ||||
app s | Test Firm Name and Contact Information | |||||
1 | Firm Name |
Dongguan Dongdian Testing Service Co.,Ltd
|
||||
1 | Name |
J****** Y****
|
||||
1 | Telephone Number |
086-0******** Extension:
|
||||
1 |
y******@163.com
|
|||||
Equipment Specifications | |||||||||||||||||||||||||||||||||||||||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
Line | Rule Parts | Grant Notes | Lower Frequency | Upper Frequency | Power Output | Tolerance | Emission Designator | Microprocessor Number | |||||||||||||||||||||||||||||||||
1 | 1 | 15C | 2402.00000000 | 2480.00000000 | 0.0033100 |
some individual PII (Personally Identifiable Information) available on the public forms may be redacted, original source may include additional details
This product uses the FCC Data API but is not endorsed or certified by the FCC